Fisker Karma (2012) - Repair, Service and Maintenance Manual

CLICK HERE FOR SAMPLE MANUAL

FISKER KARMA (2012) - WORKSHOP, SERVICE, REPAIR MANUAL

- English Service Manual / Repair Manual, for vehicles Fisker Karma (2012).

 CONTENTS:

ENGINE
- Mounting - LH
- Mounting - RH
- Engine and Generator - Remove and Refit for Access
- Gasket - Cylinder Head
- Oil Seal - Crankshaft - Rear
- Oil - Drain and Refill
- Filter - Oil
- Gasket - Camshaft Cover
- Gasket - Timing Cover
- Oil Seal - Timing Cover
- Cover - Engine
- Thermostat
- Water Pump
- Module - Engine Control (ECM)
- Sensor - Oil Pressure
- Sensor - Turbocharger Boost Pressure and Temperature
- Sensor - Manifold - Mass Air Flow and Temperature (MAFIAT)
- Modulator - Turbocharger Boost Pressure
- Sensor - Coolant Temperature
- Sensor - Ambient Air Temperature
- Sensor - Crankshaft Position (CKP)
- Sensor - Inlet - Camshaft Position (CMP)
- Sensor - Knock (KS) - Front
- Plug Top Ignition Coil - Each
- Plug Top Ignition Coil - Set
- Spark Plugs - Set
- Sensor - Manifold Absolute Pressure (MAP)
- Solenoid - Camshaft Timing
- Sensor - Oxygen - Upstream
- Sensor - Oxygen - Downstream
- Fuel Tank
- Module - Sender - Fuel level
- Fuel Rail
- Injector - Each
- Injector - Set
- Regulator - Fuel Pressure
- Module - Fuel Tank Pump
- Fuel Pump - High Pressure
- Purge Valve
- Air Cleaner Assembly
- Element - Air Cleaner
- Intake Manifold Gasket
- Throttle body
- Intercooler - (Charge Air Cooler)
- Muffler Assembly - LH
- Exhaust System Complete - Remove and Refit for Access
- Exhaust manifold gasket
- Muffler Assembly - Center
- Turbocharger
- Catalyst - Exhaust
ELECTRIC DRIVE
- Generator
- Mounting - Generator to Body
- Shaft Coupler - Generator
- Battery - High Voltage - Isolation - Manual Service Disconnect - (MSD)
- Battery Assembly
- Fuse - Battery Assembly
- Charging Port
- AC/DC Inverter - From Generator
- Inverter 3 Phase AC - LH
- DC/DC Converter
COOLING SYSTEM
- Coolant - Engine and Cabin - Drain and Refill
- Coolant - Battery - Low Temp - Drain - Refill and Bleed
- Coolant - Low Temp - Motors, Generators and Inverters - Drain and Refill
- Pump - Coolant - Auxiliary Heating
- Pump - Coolant - Low Temp - Generator and DC/DC - Front
- Pump - Low Temp - Coolant - Rear
- Pump - Coolant - Low Temperature - Battery Cooling
- Radiator Pack
- Cooling Fan Assembly
- Module - Cooling Fan Speed
- Radiator - Low Temp - LH
- Cooling Fan Assembly - Low Temp - LH
- Coolant Reservoir Assembly - High Voltage Battery
- Heater - Electric - PTC
- Chiller with TXV - Low Temp Battery Cooling
HVAC SYSTEM
- Refrigerant - Recovery and Recharge
- HVAC Assembly
- Air Temperature Actuator - LH
- Mode Actuator
- Recirculation Actuator
- Heater Core
- Blower Motor
- Compressor
- Condenser
- Evaporator
- Thermal Expansion Valve (TXV)
- Switch - AC - System Pressure
- Sensor - HVAC - Core Temperature
- Pollen Filter
- Face Level Vent - Outboard
- Face Level Vent - Inboard
FINAL DRIVE
- Differential - Oil Level - Check
- Differential - Oil - Drain and Refill
- Oil Seal - Differential - Input
- Oil Seal - Differential - Output - LH
- Half Shaft Assembly - LH
- Gaiter - Half Shaft - Inner - LH
- Gaiter - Half Shaft - Outer - LH
- Joint Assembly - Inner - LH
- CV Joint Assembly - Outer - LH
- Differential Assembly
- Rear Drive Module-RDM Service
STEERING
- Steering Wheel
- Column - Complete
- Column - Lower
- Steering Rack
- Pump - Power Steering Fluid
- Power Steering - Refill and Bleed
- Power Steering - Drain and Replenish
SUSPENSION
- Four Wheel Alignment Check
- Spring and Shock Absorber Assembly - Front - LH
- Shock Absorber - Front - LH
- Spring and Shock Absorber Assembly - Rear - LH
- Shock Absorber - Rear - LH
- Lower Arm - Front - LH
- Upper Wishbone - Front - LH
- Lower Arm - Rear - LH
- Upper Wishbone - Rear - LH
- Tie Rod End - Front - LH
- Toe Link - Rear - LH
- Link - Sway Bar - Front - LH
- Sway Bar - Front
- Link - Sway Bar - Rear - LH
- Sway Bar - Rear
- Hub - Front - LH
- Upright - Suspension - Front - LH
- Hub - Rear - LH
- Upright - Suspension - Rear - LH
BRAKES
- Bleed Procedure - System
- Brake Fluid Reservoir
- Master Cylinder
- Electronic Brake Control Module (EBCM)
- Sensor - ABS - Rear - LH
- Sensor - ABS - Front - LH
- Brake Rotor - Front - LH
- Brake Caliper - Front - LH
- Brake Rotor - Rear - LH
- Brake Caliper - Rear - LH
- Brake Pads - Front
- Brake Pads - Rear
- Motor - Parking Brake
- Parking Brake Cable - Adjust
- Cable - Cable Link to Hub - LH
- Park Brake Shoes - Adjust
- Park Brake Shoes
WHEELS & TIRES
- Wheel - Remove for Access
- Tire - Each
- Wheel Sensor - TPMS
CHASSIS
- Subframe Assembly - Rear
- Subframe - Front
- Subframe - Rear
- Cross Brace - LH
- Cross Brace - Front
- Closing Panel - Tunnel
- Closing Panel - High Voltage Cables
BODY
- Diffuser - Rear - Closing Panel
- Closing Panel - Bumper - Front
- Cover - Charging Port
- Cover - Fuel Filler
- Housing - Fuel Filler Neck Assembly
- Fender - Front - LH
- Bumper Assembly - Front
- Bumper Assembly - Front - Remove and Refit for Access
- Reinforcement - Bumper Assembly - Front
- Armature Assembly - Bumper - Rear
- Bumper Assembly - Rear
- Bumper Assembly - Rear - Remove and Refit for Access
- Rocker Panel Finisher - LH
- Hood Assembly
- Hinge - Hood Assembly - LH
- Latch Assembly - Hood - LH
- Release Cable - Hood
- Release Handle - Hood
- Alignment - Hood - Check and Adjust
- Trunk Lid Assembly
- Hinge Trunk Lid - LH
- Strut - Trunk Assembly - LH
- Latch Assembly - Trunk Lid
- Striker - Trunk Lid
- Alignment - Trunk Lid - Check and Adjust
- Closing Panel - Trunk
- Door - Front - LH
- Hinge - Upper - Front - LH
- Hinge - Lower - Front - LH
- Check Strap - Door - Front - LH
- Front Door Alignment - Check and Adjust
- Door - Rear - LH
- Hinge - Upper - Rear - LH
- Hinge - Lower - Rear - LH
- Check Strap - Door - Rear - LH
- Rear Door Alignment - Check and Adjust
- Latch Assembly - Door - Front - LH
- Latch Assembly - Door - Rear - LH
- Handle - Door - Outer - Front - LH
- Handle - Door - Outer - Rear - LH
- Seal - Flag 'A' post - LH
- Seal - Door/Roof - Header - LH
- Seal - Door Primary lower - Front - LH
- Seal - Door Primary lower - Rear - LH
- Seal - Waist Rail - Outer - Front
- Seal - Waist Rail - Outer - Rear
- Seal - Waist Rail - Inner - Front
- Seal - Waist Rail - Inner - Rear
- Seal - Front Door - Fender - LH
- Seal - Front Door - Cut Line - LH
- Seal - Rear Door - Cut Line - LH
- Molding - Roof Ditch - LH
ROOF
- Solar Roof Assembly
GLAZING
- Alignment - Door Glass - Single
- Alignment - Door Glass - Rear Quarter
- Alignment - Door Glass - Rear
- Front Screen
- Rear View Mirror
- Rear Screen
- Door Glass - Front
- Door Glass - Rear
- Door Glass - Guide Rail - Rear
- Glass - Rear Quarter
- Regulator - Front - LH
- Regulator - Rear - LH
EXTERIOR FITTINGS
- Liner - Wheel Arch - Front - LH
- Liner - Wheel Arch - Rear - LH
- Plenum Cover
- Mirror Assembly - LH
DASH ASSEMBLY
- Sensor - Accelerator Pedal Position (APP)
- Brake Pedal Assembly
- Dash Assembly
- Topper Panel
- Trim Panel - Dash - Passenger
- Switch Housing - Centre Stack - Upper
- Knee Airbag Closing Panel - Driver
- Closing Panel - Dash - Passenger
- Closing Panel - Dash - Driver
INTERIOR TRIM
- Handle - Door - LH
- Cover - Door - Front - LH
- Cover - Door - Rear - LH
- Cowl - Steering Column - Upper
- Cowl - Steering Column - Lower
- Carpet Assembly - LH
- Finisher - 'A' Post Upper - LH
- Finisher - 'A' Post Lower Trim - LH
- Finisher - 'B' Post Upper - LH
- Finisher - 'B' Post Lower - LH
- Finisher - 'D' Post - LH
- Center Console - Front
- Center Console - Storage Compartment - Front
- Center Console - Rear
- Glovebox Cover
- Glovebox
- Headlining
- Finisher - Rear Bulkhead
- Finisher - Parcel Shelf
- Finisher - Trunk Lid
- Finisher - Trunk Floor
- Finisher - Trunk Side - LH
- Finisher - Trunk Trim - Front
RESTRAINT SYSTEMS
- Belt - Pre-Tensioner - Driver
- Belt - Passenger - Rear
- Airbag - Driver - Front
- Airbag - Driver - Knee
- Airbag - Driver - Curtain
- Airbag - Driver - Side / Thorax
- Airbag - Passenger - Front
- Airbag - Passenger - Knee
- Mounting - Passenger Seat - Rear
- Mounting - Tether - Rear
SEATS
- Seat Assembly - Driver
- Seat Cushion - Rear - LH
- Seat Squab - Rear - LH
- Seat Runners - Driver
- Motor Seat - Runner - Driver
- Motor Seat - Lumbar - Driver
- Sensor - Position - Seat Runner
- Motor Seat - Recline - Drivers
- Motor Seat - Height - Drivers
- Module - Seat Control
- Cover - Cushion - Front
- Cover - Cushion - Rear
- Cover - Squab - Front
- Cover - Squab - Rear
- Switch Cover - Driver
ELECTRICAL
- Isolation Procedure - Battery - 12V
- Battery - 12V
- Harness - Fuel Injector
- Switch - Engine Start/Stop
- Switch - PRND
- Hybrid Control Module - HCM
- Module - Vehicle Control (VCM)
- Module - Park Distance Control - (PDC)
- Module - Parking Brake
- Module - Seat Control - Front
- Module - Seat Control - Rear
- Module - Air Conditioning - (AC)
- Module - External Speaker Controller / Amplifier
- Module - Inertia Unit - (IMU)
- Module - Heated Seat Memory - (HSMM)
- Instrument Panel
- Switch - Exterior Mirror
- Clock Spring
- Switch Assembly - Seat - Driver
- Under Seat Lamp
- Socket - Auxiliary Power - Rear
- Socket - USB Charging - Rear
- Camera - Rear Mounted
- Sensor - Parking Distance - Rear - Each
- Horn Assembly
- Speaker - External - Rear
- Module - External Speaker Control
- Headlamp Assembly - LH
- Headlamp - Both - Alignment
- Central High Mounted Stop Lamp (CHMSL)
- Rear Lamp Cluster - LH
- Rear Lamp - Fog and Reverse - Bumper
- Wiper Motor Assembly
- Wiper Arm Assembly
- Reservoir - Washer Fluid
- Pump - Washer Fluid
- Jet - Headlamp Washer
INFOTAINMENT
- Central Infotainment Unit - CIU
RDM
- Slide Number 1
- Slide Number 2
- Slide Number 3
- Slide Number 4
- Slide Number 5
- Slide Number 6
- Rear bumper assembly
- Rear bumper assembly
- Rear bumper assembly
- Rear bumper assembly
- Remove Subframe Assembly- Rear
- Remove Subframe Assembly- Rear
- Remove Subframe Assembly- Rear
- Remove Subframe Assembly- Rear
- Remove Subframe Assembly- Rear
- Remove Subframe Assembly- Rear
- Remove Subframe Assembly- Rear
- Remove Subframe Assembly- Rear
- Remove Subframe Assembly- Rear
- Remove Subframe Assembly- Rear
- Remove Subframe Assembly- Rear
- Remove Subframe Assembly- Rear
- Remove Subframe Assembly- Rear
- Remove RDM from Subframe
- Remove RDM from Subframe
- Remove RDM from Subframe
- Remove RDM from Subframe
- RDM
- RDM
- RDM
- RDM
- HVIL plates
- Remove RDM
- Remove RDM
- RDM Inspection
- RDM Inspection
- Loctite Preparation
- RDM Install
- RDM Install
- RDM Install
- RDM Install
- RDM Install
- RDM Install
- RDM Install
- RDM Install
- Cooling system bleeding
- Cooling system bleeding
- Cooling system bleeding
- Cooling system bleeding
- Slide Number 50
- Rear Suspension
- Torque spec
- Torque spec
- Slide Number 54