Toyota Prius W11 W20 W30 (2001-2015) - Service Manual, Wiring Diagrams and Owners Manual

CLICK HERE FOR SAMPLE MANUAL

TOYOTA PRIUS 2001-2015 (W11, W20, W30) - WORKSHOP, REPAIR, SERVICE MANUAL - WIRING - OWNERS

- English Service Manual to vehicles Toyota Prius W11 W20 W30 (2001-2015)


INDEX:

SERVICE MANUAL


- GENERAL
- INTRODUCTION
- FOREWORD
- FOREWORD
- CAUTION
- HOW TO TROUBLESHOOT ECU CONTROLLED SYSTEMS
- GENERAL INFORMATION
- ELECTRONIC CIRCUIT INSPECTION PROCEDURE
- HOW TO PROCEED WITH TROUBLESHOOTING
- HOW TO USE THIS MANUAL
- GENERAL INFORMATION
- REPAIR INSTRUCTION
- PRECAUTION
- RISKS
- VEHICLE LIFT AND SUPPORT LOCATIONS
- CUSTOMIZE PARAMETERS
- DOOR LOCK
- ILLUMINATED ENTRY
- WIRELESS DOOR LOCK CONTROL SYSTEM
- ILLUMINATED ENTRY
- SMART KEY/ACCESS
- WARNING
- SMART KEY/ACCESS
- ILLUMINATED ENTRY
- WARNING
- COMBINATION METER
- AIR CONDITIONER
- LIGHT CONTROL
- INITIALIZATION
- INSPECTION MODE PROCEDURE
- TERMS & ABBREVIATIONS
- ABBREVIATIONS USED IN MANUAL
- GLOSSARY OF SAE AND TOYOTA TERMS
- MAINTENANCE
- BODY
- BRAKE
- CHASSIS
- ENGINE
- INSIDE VEHICLE
- OUTSIDE VEHICLE
- UNDER HOOD
- VEHICLE IDENTIFICATION AND SERIAL NUMBERS
- AUDIO, VISUAL, & TELEMATICS
- AUDIO & VIDEO
- AMPLIFIER ANTENNA
- COMPONENTS
- INSTALLATION
- REMOVAL
- AUDIO & VISUAL SYSTEM
- DIAGNOSTIC TROUBLE CODE CHART
- DTC CHECK - CLEAR
- HOW TO PROCEED WITH TROUBLESHOOTING
- IDENTIFICATION OF NOISE SOURCE
- PARTS LOCATION
- PRECAUTION
- PROBLEM SYMPTOMS TABLE
- SYSTEM DESCRIPTION
- SYSTEM DIAGRAM
- TERMINALS OF ECU
- 01-21,01-22,01-2E ROM ERROR
- 01-D5,01-D8,01-D9,01-DB,01-DE - ABSENCE OF REGISTRATION UNIT
- 01-D6,01-D7 - NO MASTER
- 01-DC - TRANSMISSION ERROR
- 01-DD,01-E1 - MASTER RESET
- 01-DF - MASTER ERROR
- 01-E0,01-E3,01-E4 - REGISTRATION COMPLETE INDICATION ERROR
- 01-E2 - ON-OFF INDICATION PARAMETER ERROR
- 01-F2,01-FF - NO RESPONSE FROM DIAGNOSIS MEMORY REQUEST
- 57-10,57-47 - TEL ECU MALFUCTION (TEL)
- 60-10,60-11 - AM TUNER PLL DOES NOT LOCK
- 60-42,60-44,60-50 - TUNER POWER SOURCE ERROR
- FRONT DOOR SPEAKER
- COMPONENTS
- INSPECTION
- INSTALLATION
- REMOVAL
- INSTRUMENT PANEL SPEAKER
- COMPONENTS
- INSPECTION
- INSTALLATION
- REMOVAL
- MICROPHONE (WITH SLIDING ROOF)
- COMPONENTS
- INSTALLATION
- REMOVAL
- MICROPHONE (WITHOUT SLIDING ROOF)
- COMPONENTS
- INSTALLATION
- REMOVAL
- NOISE FILTER
- COMPONENTS
- INSPECTION
- INSTALLATION
- REMOVAL
- RADIO ANTENNA CORD
- COMPONENTS
- INSTALLATION
- REMOVAL
- RADIO RECEIVER
- COMPONENTS
- INSTALLATION
- REMOVAL
- REAR DOOR SPEAKERS
- COMPONENTS
- INSPECTION
- INSTALLATION
- REMOVAL
- SATELLITE RADIO TUNER
- COMPONENTS
- INSTALLATION
- REMOVAL
- STEREO COMPONENT AMPLIFIER
- COMPONENTS
- INSTALLATION
- REMOVAL
- STEREO JACK ADAPTER ASSEMBLY
- COMPONENTS
- INSTALLATION
- REMOVAL
- CELLULAR COMMUNICATION

- BACKUP BATTERY
- COMPONENTS
- INSTALLATION
- REMOVAL
- DCM
- COMPONENTS
- INSTALLATION
- REMOVAL
- MANUAL (SOS) SWITCH
- COMPONENTS
- INSTALLATION
- REMOVAL
- SAFETY CONNECT SYSTEM
- PRECAUTION
- PARTS LOCATION
- SYSTEM DIAGRAM
- SYSTEM DESCRIPTION
- HOW TO PROCEED WITH TROUBLESHOOTING
- DCM OPERATION HISTORY
- DCM ACTIVATION
- HEALTH CHECK
- ACN CALL END
- PROBLEM SYMPTOMS TABLE
- TERMINALS OF ECU
- DIAGNOSIS SYSTEM
- DTC CHECK-CLEAR
- PRL UPDATE
- DATA LIST - ACTIVE TEST
- DIAGNOSTIC TROUBLE CODE CHART
- B1570 MANUAL (SOS) SWITCH RED INDICATOR MALFUNCTION
- B1571 MANUAL (SOS) SWITCH GREEN INDICATOR MALFUNCTION
- B1572 TELEPHONE MICROPHONE ERROR
- B1573,B15CB SHORT IN TELEPHONE ANTENNA CIRCUIT
- B1583 GPS SIGNAL UNRECEIVED
- B15A8 TELEMATICS TRANSCEIVER MALFUNCTION
- B15C0,B15C1 SHORT IN GPS ANTENNA
- B15C4 AIRBAG SIGNAL MALFUNCTION-NOT INPUT
- B15C5 MANUAL BUTTON MALFUNCTION
- B15CC BACKUP BATTERY FAILURE
- B15EC BACKUP BATTERY DEGREDATION
- DCM POWER SOURCE CIRCUIT
- GREEN AND RED INDICATORS BLINK SIMULTANEOUSLY
- GREEN AND RED INDICATORS DO NOT COME ON WHEN IG-ON
- GREEN INDICATOR REMAINS OFF
- RED INDICATOR REMAINS ON
- UNABLE TO CONNECT TO CALL CENTER
- TELEPHONE AND GPS ANTENNA CORDS
- COMPONENTS
- REMOVAL
- INSTALLATION
- TELEPHONE AND GPS ANTENNA
- COMPONENTS
- REMOVAL
- INSTALLATION
- TELEPHONE MICROPHONE (WITH SLIDING ROOF)
- COMPONENTS
- REMOVAL
- INSTALLATION
- TELEPHONE MICROPHONE (WITHOUT SLIDING ROOF)
- COMPONENTS
- REMOVAL
- INSTALLATION
- GARAGE DOOR OPENER SYSTEM
- PARTS LOCATION
- SYSTEM DIAGRAM
- REGISTRATION
- SYSTEM DESCRIPTION
- ON-VEHICLE INSPECTION
- NAVIGATION & MULTI INFO DISPLAY
- NAVIGATION ANTENNA
- COMPONENTS
- REMOVAL
- INSTALLATION
- NAVIGATION RECEIVER
- COMPONENTS
- INSTALLATION
- REMOVAL
- NAVIGATION SYSTEM
- PRECAUTION
- PARTS LOCATION
- SYSTEM DIAGRAM
- SYSTEM DESCRIPTION
- HOW TO PROCEED WITH TROUBLESHOOTING
- OPERATION CHECK
- PROBLEM SYMPTOMS TABLE
- TERMINALS OF ECU
- DTC CHECK - CLEAR
- DIAGNOSTIC TROUBLE CODE CHART
- B1561,B159F XM TUNER DISCONNECTED (COMMAND LINE)
- B1562 XM TUNER DISCONNECTED (BURST MODE)
- B1582 MAP DISK READING MALFUNCTION
- B1593,B15D3 NO RESPONSE FROM STEREO COMPONENT AMPLIFIER
- B15A0,B15AD,B15B0,B15B3,B15B7 LAN MASTER MALFUNCTION
- B15A3 STEREO COMPONENT AMPLIFIER MALFUNCTION
- B15BA XM TUNER MALFUNCTION
- B15C0,B15C1 SHORT IN GPS ANTENNA
- B15C2 SPEED SIGNAL MALFUNCTION
- B15D8 MONITOR DISCONNECTED
- B15E1 MEDIA MALFUNCTION
- B15FE,B15FF XM TUNER ANTENNA DISCONNECTED
- U0073 CONTROL MODULE COMMUNICATION BUS OFF
- SATELLITE RADIO BROADCAST CANNOT BE RECEIVED
- TRAFFIC INFORMATION IS NOT DISPLAYED
- NOISE OCCURS
- PRESSING POWER SWITCH DOES NOT TURN ON SYSTEM
- NO SOUND CAN BE HEARD FROM SPEAKERS
- CD CANNOT BE EJECTED
- CD CANNOT BE INSERTED - PLAYED OR CD IS EJECTED RIGHT AFTER INSERTION
- CD SOUND SKIPS
- RADIO BROADCAST CANNOT BE RECEIVED OR POOR RECEPTION
- ILLUMINATION FOR PANEL SWITCH DOES NOT COME ON WITH TAIL SWITCH ON
- DISPLAY DOES NOT DIM WHEN LIGHT CONTROL SWITCH IS TURNED ON
- PANEL SWITCHES DO NOT FUNCTION
- TOUCH PANEL SWITCH DOES NOT FUNCTION
- DISPLAY PANEL DOES NOT OPEN, TILT OR TILTS IMPROPERLY
- SCREEN FLICKER OR COLOR DISTORTION
- POOR SOUND QUALITY IN ALL MODES (LOW VOLUME)
- MAP DISC CANNOT BE INSERTED
- VEHICLE POSITION MARK DEVIATES GREATLY
- CURSOR OR MAP ROTATES WHEN VEHICLE STOPPED
- VEHICLE POSITION MARK IS NOT UPDATED
- CURRENT POSITION DISPLAY DOES NOT APPEAR
- GPS MARK IS NOT DISPLAYED
- VOICE GUIDANCE DOES NOT FUNCTION
- MAP DISPLAY INCOMPLETE
- ROUTE CANNOT BE CALCULATED
- VOICE RECOGNITION DIFFICULTY
- VOICE IS NOT RECOGNIZED
- CELLULAR PHONE REGISTRATION FAILURE, PHONE DIRECTORY TRANSFER FAILURE
- CELLULAR PHONE CANNOT SEND-RECEIVE
- CANNOT CALL IN A CERTAIN PLACE
- THE OTHER CALLER'S VOICE CANNOT BE HEARD, IS TOO QUIET, OR DISTORTED
- THE OTHER CALLER CANNOT HEAR YOUR VOICE, OR YOUR VOICE IS TOO QUIET OR DISTORTED
- SOUND OF PORTABLE PLAYER CANNOT BE HEARD FROM SPEAKERS OR SOUND IS LOW
- DOES NOT PLAY EVEN AFTER BLUETOOTH AUDIO MODE IS SELECTED
- NOISE OCCURS OR SOUND SKIPS WHEN PORTABLE PLAYER PLAYS
- PORTABLE PLAYER CANNOT BE CONNECTED MANUALLY-AUTOMATICALLY
- REGISTERED DEVICE CANNOT BE DELETED
- PORTABLE PLAYER CANNOT BE REGISTERED
- BLACK SCREEN
- STEERING PAD SWITCH CIRCUIT
- ILLUMINATION CIRCUIT
- PARKING BRAKE SWITCH CIRCUIT
- SPEAKER CIRCUIT
- SOUND SIGNAL CIRCUIT BETWEEN NAVIGATION RECEIVER ASSEMBLY AND STEREO COMPONENT AMPLIFIER
- SOUND SIGNAL CIRCUIT BETWEEN NAVIGATION RECEIVER ASSEMBLY AND STEREO JACK ADAPTER
- SOUND SIGNAL CIRCUIT BETWEEN NAVIGATION RECEIVER ASSEMBLY AND STEREO COMPONENT TUNER ASSEMBLY
- MUTE SIGNAL CIRCUIT BETWEEN NAVIGATION RECEIVER ASSEMBLY AND STEREO COMPONENT AMPLIFIER
- MUTE SIGNAL CIRCUIT BETWEEN NAVIGATION RECEIVER ASSEMBLY AND STEREO COMPONENT TUNER ASSEMBLY
- MUTE SIGNAL CIRCUIT BETWEEN STEREO COMPONENT AMPLIFIER AND TELEMATICS TRANSCEIVER
- AVC-LAN CIRCUIT
- VEHICLE SPEED SIGNAL CIRCUIT BETWEEN STEREO COMPONENT AMPLIFIER AND COMBINATION METER
- REVERSE SIGNAL CIRCUIT
- NAVIGATION VOICE CIRCUIT
- MICROPHONE CIRCUIT BETWEEN MICROPHONE AND NAVIGATION RECEIVER ASSEMBLY
- STEREO COMPONENT AMPLIFIER POWER SOURCE CIRCUIT
- NAVIGATION RECEIVER ASSEMBLY POWER SOURCE CIRCUIT
- PARK ASSIST & MONITORING
- ADVANCED PARKING GUIDANCE SYSTEM
- PRECAUTION
- PARTS LOCATION
- SYSTEM DIAGRAM
- SYSTEM DESCRIPTION
- HOW TO PROCEED WITH TROUBLESHOOTING
- INITIALIZATION
- CALIBRATION
- PROBLEM SYMPTOMS TABLE
- TERMINALS OF ECU
- DIAGNOSIS SYSTEM
- DTC CHECK - CLEAR
- DATA LIST - ACTIVE TEST
- DIAGNOSTIC TROUBLE CODE CHART
- C1611 ECU MALFUNCTION
- C1612 IG VOLTAGE IS LOW OR HIGH
- C1613 ACC VOLTAGE IS LOW OR HIGH
- C1621, C1622 - BACK CAMERA POWER SUPPLY FAILURE
- C1625 - OPEN OR SHORT IN STEERING ANGLE SENSOR +B
- C1662 - STEERING ANGLE SENSOR FAILURE
- C168B C168C - AVC-LAN COMMUNICATION MALFUNCTION
- C1691 - BACK CAMERA INITIALIZATION INCOMPLETE
- C1694 - STEERING ANGLE INITIALIZATION INCOMPLETE
- C1695 - ZERO POINT CALIBRATION OF VEHICLE HEIGHT SENSOR INCOMPLETE
- C1AE0 - FRONT LEFT SIDE SENSOR
- C1AE5 - FRONT RIGHT SIDE SENSOR
- C1AEE - APGS SENSOR COMMUNICATION CIRCUIT
- U0073, U0126, U1029, U0131, U0140, R0293 - CONTROL MODULE COMMUNICATION BUS OFF
- U1000 - CAN COMMUNICATION FAILURE(MESSAGE REGISTRY)
- IMAGE FROM CAMERA FOR ADVANCED PARKING GUIDANCE IS ABNORMAL
- VEHICLE DOES NOT MOVE TO SET PARKING POSITION
- CHK MESSAGE(S) ARE DISPLAYED ON THE SIGNAL CHECK SCREEN.
- MESSAGE INDICATING BACK DOOR IS OPEN IS DISPLAYED EVEN AFTER BACK DOOR IS CLOSED
- ECU POWER SOURCE CIRCUIT
- PARK ASSIST ECU
- COMPONENTS
- REMOVAL
- INSTALLATION
- PARKING ASSIST PRE SUPPORT SWITCH
- COMPONENTS
- REMOVAL
- INSPECTION
- INSTALLATION
- REAR VIEW MONITOR SYSTEM (WITH NAVIGATION SYSTEM)
- PRECAUTION
- PARTS LOCATION
- SYSTEM DIAGRAM
- SYSTEM DESCRIPTION
- HOW TO PROCEED WITH TROUBLESHOOTING
- PROBLEM SYMPTOMS TABLE
- TERMINALS OF ECU
- DTC CHECK - CLEAR
- DIAGNOSTIC TROUBLE CODE CHART
- C1622 - OPEN OR SHORT CIRCUIT IN BACK CAMERA SIGNAL
- IMAGE FROM CAMERA FOR REAR VIEW MONITOR IS ABNORMAL
- REAR VIEW MONITOR SYSTEM (WITHOUT NAVIGATION SYSTEM)
- PRECAUTION
- PARTS LOCATION
- ILLUSTRATION
- SYSTEM DIAGRAM
- SYSTEM DESCRIPTION
- HOW TO PROCEED WITH TROUBLESHOOTING
- RESULT
- RESULT
- PROBLEM SYMPTOMS TABLE
- GENERAL
- DISPLAY MALFUNCTION
- TERMINALS OF ECU
- DESCRIPTION
- WIRING DIAGRAM
- INSPECTION PROCEDURE
- PROCEDURE
- DESCRIPTION
- WIRING DIAGRAM
- INSPECTION PROCEDURE
- PROCEDURE
- TEXT IN ILLUSTRATION
- DESCRIPTION
- WIRING DIAGRAM
- INSPECTION PROCEDURE
- PROCEDURE
- TELEVISION CAMERA
- COMPONENTS
- ILLUSTRATION
- REMOVAL
- INSTALLATION
- ULTRASONIC SENSOR
- COMPONENTS
- ILLUSTRATION
- ILLUSTRATION
- REMOVAL
- INSPECTION
- INSTALLATION
- BRAKE
- FRONT BRAKE
- COMPONENTS
- REMOVAL
- DISASSEMBLY
- INSPECTION
- REASSEMBLY
- INSTALLATION
- REAR BRAKE
- COMPONENTS
- REMOVAL
- DISASSEMBLY
- INSPECTION

AND MORE....