Skoda 102 105 S L LE LS LSE - Service Repair Manual - Wiring Diagrams

CLICK HERE FOR SAMPLE MANUAL

SKODA 105 S, 105 L, 120 L, 120 LE, 120 LS, 120 LSE - WORKSHOP, SERVICE, REPAIR MANUAL - WIRING DIAGRAMS

- English Service Manual and Wiring Diagrams, for cars Skoda 102 105 S L LE LS LSE.

 
CONTENTS:

Introduction
General technical information
- General Characteristics of Cars
- Identification Plates and Numbers, Keys
- Functional Car Equipment
- Car Jacking-up Equipment
- Spare Wheel and Fuel Tank
- Starting the Engine
- Technical Data (dimensional, performance and other data)
- Tightening Torques of Bolts, Screws and Nuts
- Physical Units
- General Instructions
Engine
- Technical Description
- Removing Engine from Car
- Refitting Engine in Car
- Reassembling Engine
- Dismantling Engine
- Brake Test and Engine Lubrication Diagram
- Cylinder Block
- Crankshaft
- Flywheel
- Cylinder
- Piston c/w Gudgeon Pin and Piston Rings
- Connecting Rod
- Cylinders, Connecting Rods and Pistons
- Valve Gear - Timing Chain
- Water Pump
- Rocker Shaft and Rockers
- Cylinder Head, Valves and Springs
- Oil Sump
- Timing Gear Cover - Oil Pump
- Carburettor
- Fuel Pump
Clutch
- Technical Description
- Removing Clutch from Engine
- Refitting Clutch in Engine
- Clutch Dismantling
- Clutch Reassembly
- Friction Plate
- Clutch Control Mechanism
Power transmission mechanisms - gearbox and final drive
- Technical Description
- Removing and Refitting Power Pack Assembly
- Assembling Gearbox
- Assembling Final Drive
- Dismantling Transmission Mechanisms
- Front Cover
- Pinion c/w Gears
- Drive Shaft c/w Gears
- Bevel Gear Drive
- Differential
- Cross Bearer
Rear axle
- Technical Description
- Dismantling and Reassembling Rear Axle in Car
- Assembling Half-axles and Radius Arms
- Dismantling Half-axles and Radius Arms
- Assembling Half-axles with Axle Housing
- Rear Axle Geometry
- Half-axle Dust Boots
- Half-axle Shaft
Front axle
- Technical Description
- Front Axle Geometry (Wheel Alignment)
- Removing Front Axle from Car
- Refitting Front Axle in Car
- Dismantling Front Axle
- Reassembling Front Axle
- Steering Knuckle
- King Pin
- King Pin Socket
Steering
- Technical Description
- Removing and Refitting Steering Box
- Dismantling Steering Box
- Reassembling Steering Box
- Relay (Idler) Lever
- Steering Linkage
- Ball Pins and Dust boots
- Steering Wheel
- Steering Wheel Shaft and Shaft Bearing
- Steering Lock
Suspension and shock absorbers
- Technical Description
- Front Springs
- Rear Springs
- Shock Absorbers
Brake system
- Technical Description
- Rear Brake Assembly
- Front Brake Assembly
- Master Cylinder
- Rear Brake Wheel Cylinder
- Front Brake Wheel Cylinder
- Brake Booster
- Brake Fluid Tank, Piping and Hoses
- Hand Brake
- Brake Fluid and Bleeding of Brakes
Wheels and tyres
- Technical Description
- Type of Wheels, Tyres and Tubes, Tyre Pressures
- Change and Interchange of Tyres
- Wheel Balancing
- Tubed Tyres
- Tubeless Tyres
- Snow Chains
Cooling system and heater
- Technical Description
- Cooling System - Filling and Draining
- Radiator
- Coolant Tank and Screw Cap
- Radiator Connecting Line
- Coolant Temperature Control
- Heater
- Heater Control and Hot Air Distribution
- Heater Connecting Line
- Oil Cooler
- Cooling System Defects, Testing, Repairs and Cleaning
Pedals, levers, operating rods, cables, pipelines, fuel tank
- Brake and Clutch Pedals, Stop-light Switch and Brake Pedal travel Signalling Switch
- Accelerator Pedal and Cable
- Gear Shift lever and Linkage
- Choke Lever and Cable
- Hand Brake Lever and Cables
- Fuel Tank and Fuel Line
- Arrangement of Pipelines, Links and Cables under the Car
- Speedometer Drive Shaft
Electrical equipment
- Technical Description
- Wiring, Fuses
- Storage Battery
- Alternator
- Voltage Regulator
- Distributor
- Ignition Coil
- Sparking Plugs and Ignition Cables
- Lighting-headlamps, Lights, Bulbs
- Horn
- Starter Motor
- Windscreen Wiper
- Radiator Fan
- Heater Fan
- Windscreen Washer - motor and Accessories
- Instrument Panel - instruments
- Switch Box
- Switches of Lamps and Warning Systems, Direction Indicator Ticker, Receptacle etc.
- Fog Lamps and Other Optional Equipment
Bodywork
- Technical Description
- Bumpers
- Wings
- Bonnet and Boot Lid
- Body Front-end and Rear-end Panel
- Doors
- Windscreen and Rear Window
- Trimming Upholstery and Weatherstrips
- Seats
- Varnishes and Paints
- Checking Underbody Dimensions
- Seat Belts
- Facia
- Water Leaks
Maintenance
- General Information
- Recommended Lubricants and Service Fluids
- Engine and its Accessories
- Clutch
- Gearbox and Final Drive Unit
- Steering
- Front Axle
- Brake System
- Gear Change Mechanism
- Wheels and Tyres, Snow Chains
- Electrical Equipment
- Bodywork - Underbody
- Cooling System and Heater
Special equipment
- Equipment for Subtropical Regions
- Equipment for Tropical Regions
Service tools
- Engine
- Clutch
- Gearbox
- Rear Axle
- Front Axle
- Steering
- Complete Car
- Miscellaneous